How much is an air conditioner blower

Replacing a blower motor costs $450 on average with a typical range of $250 to $800. With a warranty, you might pay as little as $150 for labor alone. For high-end models, like those with large motors or access issues, you might pay as much as $2,000.

How much does it cost to replace an AC blower?

Replacing a blower motor costs $450 on average with a typical range of $250 to $800. With a warranty, you might pay as little as $150 for labor alone. For high-end models, like those with large motors or access issues, you might pay as much as $2,000.

How long does an AC blower last?

The average lifespan of an AC fan motor is about 12 years. An AC fan motor can last more than 12 years if it’s kept clean and cooled as needed. On the other hand, without annual maintenance checkups, your fan motor may only survive between one and three years.

How do I know if my AC blower motor is bad?

1. AC Fan Doesn’t Start. Even though you have the AC turned on, the fan does not start.
2. AC Fan Doesn’t Stop. …
3. Slow Rotating Blades. …
4. Outside Fan Blades Are Still. …
5. Rattling, Humming, and Buzzing Noises. …
6. AC Runs Intermittently. …
7. No Cold Airflow.

What causes AC blower to stop working?

One of the most common reasons fans stop spinning is because of a dead capacitor. … Each air conditioning system has several capacitors, including the start capacitor, which sends signals to the motor, and the run capacitor, which keeps the motor running. Capacitors can go bad over time and need to be replaced.

How much does a blower cost for a furnace?

AC Blower Motor Cost. Whether you’re looking at a furnace blower or an AC blower, both have the same average cost of $250 to $800.

Is it hard to replace a blower motor?

If you don’t want to sweat or shiver, then find a good mechanic. The replacement of the blower motor is common and straightforward, so most shops will perform the repair — many on the same day.

What happens when blower motor goes bad?

Overheating is One of the Symptoms of a Bad Blower Motor in HVAC. If the HVAC system starts to overheat, you will smell something burning. Some systems will shut down right away when this happens.

What happens when the blower motor goes out?

You might also hear ongoing whirring noises, or noises that change or get louder if you increase the fan speed. These are all signs of problems with the blower motor. In some cases, you may even notice smoke or smells of burning while driving, in which case you should pull over immediately.

Can you fix a blower motor?

There are a number of things that can go wrong with your heating system, but if the air stops blowing altogether and the same is true on cold air settings, a blower motor replacement is likely in order. The good news is that it’s a fairly straight forward repair.

Article first time published on

What does a bad blower motor sound like?

A defective blower motor will make a continuous sound noticeable by the passengers in the vehicle. It can manifest as a knocking, whirring, clunking, vibrating, squealing, or whining noise that persists until the blower motor is replaced.

How often do AC blower motors go out?

Is it part of a home heating system or on a commercial property furnace system? Even though the manufacturer states their blower motor will last two decades, we advise all clients to expect a 10-20-year life span due to age, use, and proactive maintenance.

How much does a fan motor for AC unit cost?

The average cost of a condenser fan motor is between $300 and $500 (not including installation). If the compressor breaks, you are looking at a much costlier problem which could cost up to $2000. In some cases, your fan motor may be under warranty.

How do I reset my AC blower?

1. Step 1: Turn off the power to the furnace. …
2. Step 2: Remove the blower compartment cover. …
3. Step 3: Make sure the blower is completely cooled off. …
4. Step 4: Locate the reset button. …
5. Step 5: Press the button in (assuming that this is your issue and that the button has popped).

How long does it take to replace a blower motor?

It takes between 45 to 90 minutes for a HVAC specialist to: replace the blower motor, adjust it, clean the fan, test it and assemble the furnace back together.

Where is the blower motor in an AC unit?

The blower motor sits inside the “air handler”, otherwise known as the indoor unit (see below).

How much is a new AC unit?

TypeUnit CostAC Installation CostTypeUnit CostAC Installation CostCentral air conditioner$1,200–$4,500$1,200–$2,200Window AC unit$150–$750N/A*Ductless mini-split$1,000–$5,500$500–$2,000

Can you replace furnace blower?

A lot of dirt and dust in your heating system can cause the blower motor to overheat. Having the heating system cleaned may fix the problem. If the blower motor hasn’t been properly maintained, it’ll eventually wear out. As a result, you’ll need to replace it.

How much is a blower resistor?

The average cost to replace the blower motor resistor at a repair shop is between $44 and $55 in parts and $70 in labor costs, for a total cost of around $114 to $125.

Why is my AC blower so loud?

If a sudden loud rattle occurs, it could mean a small piece of debris got stuck in the outdoor air conditioner’s compressor fan. … The outdoor unit’s compressor has gone bad due to age or malfunction. The indoor unit’s blower motor is old or has malfunctioned. The indoor unit’s belt is worn or misaligned.

Can a blower motor cause a fire?

The blower motor ends up running for much longer periods of time, making it prone to overheating. Any overheating furnace component is a serious problem. If temperatures climb too high, components such as the blower motor may catch on fire.

What causes a noisy air conditioner?

If your air conditioner is making a shrieking noise, this is an indicator of an issue with the fan motor. This sound may also be caused by a broken motor in the compressor of the condenser system. A screeching or squealing noise may also be caused by a damaged blower fan motor inside your house.

Can you drive with a bad blower motor?

A bad heater blower motor will not affect the safety of your car, with the possible exception of you not being able to clear the windshield of snow, ice, or condensation if the defrosters don’t work. But you won’t be comfortable inside your car, especially during the cold of winter and the heat of summer.

How long does a blower last?

The blower motor in your home or office should last anywhere from 10 to 20 years. Modern sealed bearings and sealed bushings can push the lifespan to its maximum of 20 years.

Can a bad blower motor cause no heat?

Problems with Your Blower Motor or Blower Motor Resistor Your blower motor is the component that pushes air through your car’s heating or cooling system. Without it, there’s no circulation of air—hot, cold, or otherwise. … Both of these components can fail, resulting in the heating system simply not working.

What to do if AC fan is not working?

Turn off the AC from the thermostat and the circuit breaker. Check the fan for any debris or components it is contacting while spinning. Using your kick-start stick to manually spin the fan makes this easier. If you notice any debris, clear it out, turn everything back on, and listen to it again while it’s running.